Product ID:CHAIN & CABLE LUBE, 19452
MSDS Date:03/13/1997
FSC:9150
NIIN:00N093370
Status Code:A
MSDS Number: CJYRH

Emergency Phone: 303-623-5716

Info Phone: 216-416-7200

Cage: 05573

Telephone: 216-416-7200

Cage: 05573

PETROLEUM LUBRICATING OIL

MEDIUM ALIPHATIC SOLVENT NAPHTHA (PETROLEUM); (ALIPHATIC

CAS: 64742-88-7

PETROLEUM GASES, LIQUEFIED, SWEETENED; (PROPANE-BUTANE

CAS: 68476-86-8

OSHA PEL 100

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: CAN CAUSE NASAL AND RESPIRATORY
IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE,
POSSIBLE UNCONSCIOUSNESS AND ASPHYXIATION. CHRONIC: PERMANENT BRAIN
AND NERVOUS SYSTEM DAMAGE HAS BEE N REPORTED. OVEREXPOSURE TO THESE
CHEMICALS HAS BEEN FOUND TO CAUSE DAMAGE TO LUNGS, HEART, LIVER,
KIDNEYS AND SPLEEN IN LAB ANIMALS. LIVER ABNORMALITIES HAVE BEEN
FOUND IN HUMANS. CONDITIONS TO AVOID : EXCESSIVE INHALATION OF
VAPORS.
Effects of Overexposure:DIZZINESS, HEADACHE, WEAKNESS, FATIGUE, NAUSEA.
Medical Cond Aggravated by Exposure:CAN CAUSE ALLERGIC RESPIRATORY
AND/OR SKIN REACTION.

First Aid:INHALATION: MOVE INDIVIDUAL TO FRESH AIR. IF BREATHING IS
DIFFICULT, ADMINISTER OXYGEN. SKIN: WASH WITH SOAP AND WATER THEN
WASH CLOTHING BEFORE REUSE. EYES: FLUSH WITH WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION. INGESTION: CALL MD IMMEDIATELY .

Flash Point:=-1.1C, 30.F
Lower Limits:1.2%
Upper Limits:N.A.
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, OR ALCOHOL FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE USED TO
COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILD-UP AND POSSIBLE
AUTOIGNITION OR EXPLOS ION WHEN EXPOSED TO EXTREME HEAT. IF WATER
IS USED, FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG THE GROUND OR MAY BE MOVED BY VENTILATION AND IGNITED
BY PILOT LIGHTS, OTHER FLAMES, SPARKS, HEATERS, SMOKING, ELECTRIC
MOTORS OR OTHER IGNITION SOURCE S AT LOCATIONS DISTANT FROM
MATERIAL HANDLING POINT.

Spill Release Procedures:ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR
ABSORBENT MATERIAL AND TRANSFER TO A CLOSED CONTAINER. ELIMINATE
ALL IGNITION SOURCES.

Handling and Storage Precautions:DO NOT STORE IN AREAS ABOVE 120F OR IN
DIRECT SUNLIGHT OR NEAR HEAT OR OPEN FLAME.
Other Precautions:STORE LARGE QUANTITIES IN BUILDING PORTECTED FOR
STORAGE OF NFPA CLASS 1C FLAMMABLE LIQUIDS.

Respiratory Protection:OPEN WINDOWS AND DOORS OR EMPLOY SUFFICIENT
VENTILATION TO ENSURE FRESH AIR ENTRY. IF IRRITATION OR DIZZINESS
IS EXPERIENCED, USE A NIOSH JOINTLY APPROVED, SELF CONTAINED
BREATHING APPARATUS WITH A FU LL FACE PIECE OPERATED IN PRESSURE
DEMANED.
Ventilation:LOCAL EXHAUST (SPECIFY RATE): SUFFICIENT TO MAINTAIN
EXPOSURE BELOW TLVS. MECHANICAL (GENERAL) (SPECIFY RATE): NONE.
SPECIAL & OTHER: NONE.
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKER GOGG CHEM SPLASH GOGGS IN
COMPLIANCE W/OSHA REG.
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
Supplemental Safety and Health
PHYSICAL DATA: PERCENT SOLID WEIGHT %: 50.

Boiling Pt:=85.C, 185.F
Vapor Pres:@ 70F 20C 38 MM HG
Vapor Density:>1 (AIR=1)
Spec Gravity:<1 (H*2O=1)
VOC Pounds/Gallon:50
pH:N.A.
Evaporation Rate & Reference:<1 (ETHER =1)
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAN LUBRICATING LIQUID OIL ODOR.
Percent Volatiles by Volume:60-65

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS AND HEAT.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE, NITROGEN
COMPOUNDS, ETC., WHEN BURNED.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:MATERIAL COLLECTED MAY BE DEPOSITED IN A POSTED
TOXIC SUBSTANCE LANDFILL IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

State Regulatory Information: